[Cumulonimbus]

The 1986 explosion that destroyed the space shuttle Challenger and killed seven astronauts shocked the nation, but for one rocket engineer the tragedy became a personal burden and created a lifelong quest to challenge the bureaucratic ethics that had caused the tragedy.

Roger Boisjoly was an engineer at solid rocket booster manufacturer Morton Thiokol and had begun warning as early as 1985 that the joints in the boosters could fail in cold weather, leading to a catastrophic failure of the casing. Then on the eve of the Jan. 28, 1986, launch, Boisjoly and four other space shuttle engineers argued late into the night against the launch.

In cold temperatures, o-rings in the joints might not seal, they said, and could allow flames to reach the rocket's metal casing. Their pleas and technical theories were rejected by senior managers at the company and NASA, who told them they had failed to prove their case and that the shuttle would be launched in freezing temperatures the next morning. It was among the great engineering miscalculations in history.

A little more than a minute after launch, flames shot out of the booster joint, melted through the nearby hydrogen fuel tank and ignited a fireball that was watched by the astronauts' families and much of the nation on television. Boisjoly could not watch the launch, so certain was he that the shuttle would blow up. In the months and years that followed, the disaster changed his career and permanently poisoned his view that NASA could be trusted to make the right decisions when matters came to life and death.

Boisjoly, 73, died of cancer Jan. 6 in Nephi, Utah, though news of his passing was known only in the southwest Utah community where he retired.

The Challenger disaster and the resulting investigation pulled back the curtain on NASA's internal culture, revealing a bureaucracy that had made safety secondary to its launch objectives and to the political support it needed to continue the shuttle program.

"It was the end of the dream," said John Pike, executive director of GlobalSecurity.org and a longtime analyst of U.S. aerospace. "Before the Challenger, you could think about the idea of going boldly where no one had gone before. The accident ended it."

Boisjoly was not the only engineer who attempted to stop the launch and suffered for blowing the whistle. Allan J. McDonald was Thiokol's program manager for the solid rocket booster and became the most important critic of the accident afterward. When he was pressed by NASA the night before the liftoff to sign a written recommendation approving the launch, he refused, and later argued late into the night for a launch cancellation. When McDonald later disclosed the secret debate to accident investigators, he was isolated and his career destroyed.

The tragedy was particularly hard on Boisjoly, who would sometimes chop wood in the Utah winter to work out his anger. In a 2003 interview with The Times, he recalled that NASA tried to blackball him from the industry, leaving him to spend 17 years as a forensic engineer and a lecturer on engineering ethics.

When the space shuttle Columbia burned up on reentry in 2003, killing its crew of seven, the accident was blamed on the same kinds of management failures that occurred with the Challenger. By that time, Boisjoly believed that NASA was beyond reform, some of its officials should be indicted on manslaughter charges and the agency abolished.

NASA's mismanagement "is not going to stop until somebody gets sent to hard rock hotel," Boisjoly said. "I don't care how many commissions you have. These guys have a way of numbing their brains. They have destroyed $5 billion worth of hardware and 14 lives because of their nonsense."

Boisjoly was born April 25, 1938, and raised in Lowell, Mass., where he graduated from the University of Massachusetts Lowell with a degree in mechanical engineering.

He is survived by his wife of 49 years, Roberta; daughters Norma Patterson and Darleen Richens, eight grandchildren and three brothers.

http://www.latimes.com/news/obituari...,2248999.story

[Billthegravedigger]

That sucks, he tried to tell them, but they would not listen. Good post !

[ices]

A great failure in engineering?

Thats funny, seeing as it was the engineers themselves who had told the idiotic people (mainly political movers n shakers) that it was going to go balls up.

Its like a military general telling a politician that sending a forceinto a certain area will be a serious error in judgement. Who gets strung out to dry you think?

[shoottokill]

yep, nasa's greediness paid off. mission 1st, safety 2nd eh. im glad funding is limited these days

[kellyhound]

big bosses hardly listen as often money and prestige is at stake.

[ices]

Originally Posted by kellyhound ↗

big bosses hardly listen as often money and prestige is at stake.

They forget to remember that mistakes cost lives and a lot of money. It embarasses the nation and makes people think more than twice about letting them loose with billions of dollars in funding.

In China or Russia those responsible would fear for their lives and the livelihoods of their families. Thats why they check on things a lot more.